Car sunroof Ford Focus 1

Tightening torque specification
Tightening torque specification Name Nm Pound foot Pound-inch Sliding roof sunroof frame mounting bolts 9 - 80 Sliding sunroof motor mounting bolts 3 - 27 Sliding...

Sunroof diagnostics and testing
Inspection and verification 1. Check the validity of the customer's complaint by using the system. 2. Perform a visual inspection for obvious signs of mechanical damage....

Sunroof Pinpoint Tests
PINPOINT TEST A: SUNROOF COVER MAKES NOISES WHEN MOVING STATES DETAILS/RESULTS/ACTIONS A1: CHECKING THE SUNROOF CABLE AND GUIDES 1 Remove the sunroof cable and guides....

Checking the water drainage system and eliminating water leaks
3-door 1. If a blockage or clogging of the drain hose is suspected, check the drain hoses by pouring 500 ml of water into the drain system and monitoring the flow of...

Checking the position of the roof hatch
1. NOTE: The sunroof must be in the closed position to perform adjustments. Remove the sunroof guide arm covers (if equipped). 2. Place a suitable plastic spacer,...

Initializing the sunroof drive motor
Update of the initialization of the electric motor of the sliding roof WARNING: The sunroof anti-pinch function does not operate while the sunroof motor initialization...

Sunroof Glass — Removal and Installation
Removal 1. Slide the sunroof blind back. 2. Remove the screws on both sides. 3. Remove the antenna. 4. Remove the sunroof glass panel. Installation 1. Position the...

Sunroof Curtain — Removal and Installation
Removal 1. Remove the sunroof glass panel. For more information, refer to the Sunroof Glass Panel chapter in this section. 2. CAUTION: Do not allow the glass panel...

Roof Sunroof Cable and Guide — Removal and Installation
Removal 1. Remove the sunroof glass panel. For more information, refer to the Sunroof Glass Panel chapter in this section. 2. Disconnect the water drainage channel. 3....

Sunroof Frame — Removal and Installation
Removal 1. NOTE: Make sure the sunroof is in the closed position. Disconnect the battery ground cable. 2. Remove the roof sheathing. For additional information, refer to...

Front Sunroof Drain Hose — Removal and Installation
General equipment: Suitable pull cord, minimum two metres long. Removal 1. Remove the headliner. Refer to Section 501-05 for additional information. 2. Disconnect the...

Rear Sunroof Drain Hose (4/5-Door/Wagon)
Removal 1. Remove the roof sheathing. For additional information, refer to Section 501-05. 2. Disconnect the lower C-pillar trim panel from the luggage compartment trim...

Rear Sunroof Drain Hose (3-Door)
Removal 1. Remove the roof sheathing. For additional information, refer to Section 501-05. 2. Remove the luggage compartment floor covering. 3. Disconnect the footrest...

Sunroof — Removal and Installation
Removal 1. NOTE: Make sure the sunroof is in the closed position. Remove the roof sheathing. For additional information, refer to Section 501-05. 2. Disconnect the drain...

Sunroof Drive Motor — Removal and Installation
Removal 1. CAUTION: To avoid damage, only pull down the overhead console trim panel far enough to release the retaining clips. Disconnect the overhead console trim panel...