Vehicle fuel system Ford Mondeo 3

Fuel system device
With a modern accelerator, the Mondeo has become a rare guest at the petrol pump. Petrol engine variants burn Euro-Super – diesel Mondeos take fuel from the diesel pump....

Fuel types and handling
Ford Mondeo petrol engines require Euro Super (ROZ 95). But they can also use Super Plus (ROZ 98). It makes sense to "accept" this type of fuel if your Mondeo, for...

Checking the ventilation and airing of the tank
ORDER OF EXECUTION Warm up the engine (to operating temperature) and let it idle. Disconnect the low pressure hose coming from the activated carbon filter from the...

Replacing the fuel filter (petrol engine)
ORDER OF EXECUTION Start the engine and let it run until the gasoline in the unit is completely used up. To be absolutely sure that there is actually no pressure, you...

Replacing the fuel filter (diesel engine)
ORDER OF EXECUTION Disconnect the wires from the battery. Carefully release the fuel lines on the filter housing and drain the fuel escaping under pressure. Remove the...

Emptying the tank without a fuel pump
The Mondeo fuel tank does not have a drain screw. Since the inlet and outlet pipes are located at the top of the tank, draining the fuel is not easy. If you do not have...

Dismantling pipelines and hoses (general instructions)
Caution: The fuel system in injection systems remains under pressure for a long time after the engine is switched off (see pressure relief valve). Therefore, when...

Fuel Pump Troubleshooting
One relay supplies the electric fuel pump with voltage. Starting from the start-up period, the pump supplies fresh fuel to the injectors. The second relay only comes...

Removing and installing the fuel pump (petrol engine)
ORDER OF EXECUTION Disconnect the battery ground wire. Empty the fuel tank and remove it from underneath the vehicle. Remove the supply and drain pipes and the...

Exhaust gas exhaust system
Exhaust systems in the childhood of automobile manufacturing had the task of only reducing the noise of fuel combustion of the "explosive engine" and sending exhaust...

Tips for working with the exhaust system
ORDER OF EXECUTION Raise the vehicle, position it horizontally and secure it so that it does not wobble. If you cannot free the rusted screw connections, try to tighten...

The question of cost — complete repair or partial replacement
Our guide covers the removal of the entire exhaust system – using the 1.8/2.0L engine as an example – from start to finish. If individual parts are replaced, only...

Low exhaust gas — ASU
We have long been accustomed to the necessary special exhaust gas tests (ASU) – passenger cars that have been on their wheels for over 30 years must be exempt from ASU....

Neutralization of exhaust gases
Example Duratec-HR: two lambda sensors in carburettor engines 1 — Pre-activated lambda sensor, 2 - After-activated lambda sensor, 3 - Catalyst, 4 - Additional noise...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Mondeo 4
Mondeo 3
Mondeo 2
Mondeo 1 and 2
Mondeo 1