Car battery and alternator Ford Mondeo 2

The rechargeable battery
Mondeo cars are equipped with 12 V nominal voltage batteries with six batteries. The battery is designed to supply electricity to the starter when starting the engine...

Checking the battery
Checking the electrolyte level The battery is either covered with a lid or has a transparent case. Since the electrolyte components may evaporate, check the electrolyte...

Battery characteristics
Nominal voltage is 12 V. The actual voltage depends on the degree of discharge of the battery; it may be higher or lower than the nominal value. The nominal capacity...

Determination of a faulty consumer
If a working battery suddenly does not supply current, this may mean that some consumer in the on-board network has completely discharged the battery. Search for a...

Precautions when handling the generator
When carrying out any work with discharge current installations, be sure to observe the following safety precautions: - Never disconnect the battery or voltage regulator...

Checking the installed generator
When the vehicle is moving, the battery charge indicator lamp should not light. Otherwise, the alternator or voltage regulator is faulty. First, check all the alternator...

Removing and installing the generator
Removing and installing a generator on a car with a 16-valve engine is more labor-intensive than removing and installing it on a car with a V6 engine. To remove the...

Generator repair
The installed generator is not repaired; if it fails, it is replaced with an interchangeable generator, which is covered by the same warranty as a new one. However, in...

Replacing generator brushes
Replace the generator brushes on a 16-valve engine as follows: Fig. 290. Fastening the generator regulator on a 16-valve engine - unscrew the regulator mounting bolts on...

Typical generator faults
Cause Method of elimination A. The red indicator lamp does not light when the ignition is turned on 1. The battery is discharged Start the engine using a jumper cable...

Starter
All starters have a solenoid switch. Starters are supplied by many manufacturers, but it is necessary to install a starter of the same design and power, since the design...

Checking the starter (on the car)
If the starter shaft does not rotate or rotates too slowly, check the battery charge level and wire connections. Turn on the starter with the lights fully on. If the...

Removing and installing the starter
The removal and installation procedure on a 16-valve engine and a V6 engine is different. Removal and installation of the starter on a 16-valve engine is carried out as...

Starter repair
If the starter is faulty, replace it with a new one. Before buying a new starter, check at a service station whether it can be used. Cause Actions A. When turning the...

Generator drive belt
Most vehicles are designed with a separate drive belt for all components located at the front of the engine. The exception is the V6 engine, where the fluid pump is...

This section is available on russian, bulgarian, belarusian, ukrainian, serbian, croatian, romanian, polish, slovak, hungarian

Mondeo 4
Mondeo 3
Mondeo 2
Mondeo 1 and 2
Mondeo 1