Contents: Passport data plate ↳ Chassis number ↳ Load distribution data plate ↳ Sign indicating special equipment ↳ Engine number ↳
The central distribution box is located on the driver's side, on the left under the instrument panel. The protected targets are indicated by symbols on the inside of the cover.
Open the cover to check or replace the fuse.
Blown fuses are identified by a break in the wire. All fuses are push-in inserted.
Warning: Turn off the ignition and all electrical equipment before replacing a fuse or relay. Replace the blown fuse with a new one rated for the same current.
| Central distribution box | ||
| fuse No. | Current(A) | Protected circuit |
| 1 | 10 | Right headlight low beam filament Right headlight beam leveling system |
| 2 | 10 | Left headlight low beam filament, left headlight beam leveling system |
| 3 | 10 | Right side light, license plate light, roof-mounted direction indicators, lighting |
| 4 | 10 | Left side light, license plate light |
| 5 | 20 | Rear window heating relay |
| 6 | 20 | Headlight washer pumps |
| 7 | 20 | Windshield heating relay |
| 8 | 3/10 | ECV module (for turbodiesel) / fuel pump (for EFI) |
| 9 | 20 | Cigarette lighter |
| 10 | 10 | Interior lighting, clock, windshield washer pump |
| 11 | 20 | Multifunctional lever |
| 12 | 10 | Headlight washer |
| 13 | 10 | Right headlight high beam, instrument panel lighting |
| 14 | 10 | Left headlight high beam filament |
| 15 | 10 | Heated seats, instrument panel lighting, heater motor, heated windows |
| 16 | 10 | Brake lights, reversing lights |
| 17 | 10 | Multifunctional lever |
| 18 | 3 | Anti-lock braking system |
| 19 | 25 | Heater motor |
| 20 | 15 | Headlight wiper/washer switch, wiper motor |
| 21 | 15 | APK switch |
| 22 | 15 | Multi-function lever, rear window washer/wiper |
| 23 | 3/25 | Delay relay (turbodiesel)/ switch-on relay (EFI) |
| 24 | 20 | Daytime running lights/low beam - high beam |
Additional fuses
| F1 | 10 | EFI engine |
| F2 | 3 | EFI engine |
| F3 | 30 | ABS |
| F4 | 30 | ABS |
| Relay in the central distribution box | |
| relay number | Connectable chains |
| A | Daytime running lights or low/high beam |
| IN | Low beam |
| WITH | Fuel pump |
| D | Pre-start heating |
| E | Electricity supply |
| F | Main power source |
| G | Power delay |
| N | Rear window heating |
| I | Not used |
| II | ABS |
| III | ABS |
| IV | Heated windshield |
| V | Rear window wiper |
| VI | APK switch |
| VII | Direction indicators |
| VIII | Headlight washer pump |
| IX | Intermittent mode of the cleaner |
| X | Heater motor |
| XI | Electric Power Injection (EFI) |
| XII | Additional nutrition |
Passport data plate
The plate located on the passenger side door sill indicates the model, weight of the vehicle, axle load and other various characteristics.
Chassis number
The chassis number is stamped below the plate.
Load distribution data plate
In addition to the identification plate, your vehicle has a load distribution plate located on the driver's side door sill. The information provided on the plate is for the Service Center only. The driver should not change the adjustment without knowing certain technical characteristics, which are known at the Service Center.
Sign indicating special equipment
An additional plate is located on the passenger side door sill on vehicles with special equipment.
Engine number
- The engine is on the right next to the generator;
- Diesel: front left above the oil pan flange;
- Turbo diesel: rear right above the oil sump flange and on the end of the cylinder block.
| Engine characteristics | |||
| Engine | 2.5L DI diesel | 2.5L DI diesel | 2.5 L turbodiesel |
| Engine capacity cm | 2496 | 2496 | 2496 |
| DIN power kW (hp) at rpm | 52 (70) 4000 | 59 (80) 4000 | 74,(100) 4000 |
| Required fuel grade | diesel fuel | diesel fuel | diesel fuel |
| Maximum continuous engine speed (rpm) | 4000 | 4000 | 4000 |
| Maximum engine speed during short-term operation (rpm) | 4400 | 4400 | 4400 |
| Idle speed (with electric fan included) | 825±25 | 825±25 | 825±25 |
| Power supply diagram | Fuel injection system | ||
| Cylinder firing order | 1-2-4-3 | ||
| Spark plugs/glow plugs (Motorcraft) | — | — | — |
| Spark gap (mm) | — | —- | — |
| Ignition system (mm) | — | — | — |
| Valve clearances (in a cold state)* Inlet Outlet | 0,20 0,38 | ||
| Engine oil filter (Motorcraft) | EFL 386 | ||
* Should be checked at least 5 minutes after the engine has been stopped
This article was borrowed from the website: FORDBOOK.ru